+86 13780308627

Dewatering of manure, biogas residue, and biogas slurry-Slope manure separator


The slope screen solid-liquid separator is mainly suitable for the solid-liquid separation of low-content suspended matter in the environmental protection industry. It mainly includes a power device and a base. The base is a frame structure with a power device in the middle.
A slope screen separator capable of reciprocating movement is installed on the base, a water separation water tank is fixed at the rear of the vehicle, and a concentration collection box is arranged at the lower front of the vehicle.

The slope screen separator is equipped with one or several layers of water filter screens. The front end of the water filter screen is equipped with a collection sliding bucket corresponding to the number of layers. The bottom of the collection sliding bucket adopts a shaft connected with a rolling plate wheel to slide down during the collection. Behind the bucket, there is a water collection and drainage box under the water filter.

The new structure of the equipment is novel, easy to operate, stable, and reliable in operation. Due to the multi-layer water filter, the removal rate of suspended solids is high, and it has the advantages of large wastewater treatment capacity, small area of the machine, and low equipment cost.
Since it is equipped with a grading collection sliding bucket and a concentration collection box, it can be recycled according to the size of the suspended particles. The utility model can reduce the content of suspended solids in industrial wastewater, and meets the requirements of environmental protection discharge.

The slope screen type solid-liquid separator is mainly used for the dehydration of livestock and poultry manure, manure, and biogas residue. This machine is suitable for the solid-liquid separation of low-concentration sewage. The slope screen type solid-liquid separator requires that the water content of the material is above 90%, and the solid particle size of the material is above 0.3mm.
Then the livestock and poultry manure and biogas slurry and manure water are separated with a separator so that the manure with higher water content will separate some water, and the water content of the treated manure will be between 40% and 60%. This moisture content will not be squeezed out by grabbing and squeezing, and it is an ideal state for treating livestock and poultry manure and biogas residue.